Hi all, bought an MG ZT-T cdti 135+ a few days ago now and after driving it for a bit I realised it was getting harder to select gears in any order. A friend of mine mentioned that it was a common fault on the 75 and in formed me of the location of the clutch fluid filler cap. Then this morning to no suprise I couldn't get any gears!
So to start, the clutch filler can be found under the dash above the clutch pedal itself I used a flat head screw driver to start undoing the cap (can be tight). Then inside there's is a bung preventing you filling her up so needs to be removed (I found that out after losing a bit of fluid) Please note that it is very tight to get to so a squeezy bottle and some piping or syringe would make it so so much easier!
Then more than likely you'll have to bless the system no hard at all! Bleed nipple can be found poking out of the gearbox in plain sight as your lookin at it under the bonnet. It'll have a 13mm collar and 8mm bleed screw
You'll need to place a rag around the filler cause you will spill a bit and also a rag under the bleed nipple.
Top up filler and pump pedal once the fill up again and repeat till fluid runs clear (mine was filthy!)
Tighten bleed nipple back up then replace filler cap and job done! I think I've mentioned everything, long winded. But hopefully it works for other people like it did for me!
Could save you an expensive garage bill, also i hope i haven't writen all this if someone else has
MG ZT-T, got no clutch
-
- Bolt Twiddler
- Posts: 23
- Joined: Mon Apr 05, 2010 10:31 am
MG ZT-T, got no clutch
If i'm not back in five minutes...... Just wait longer!
(Jim Carey, Ace Ventura)
(Jim Carey, Ace Ventura)
Re: MG ZT-T, got no clutch
Just remember to keep an eye on it as failure of the slave cylinder means fluid slowly leaks out. To change the slave you need to remove the gearbox.
-
- Bolt Twiddler
- Posts: 23
- Joined: Mon Apr 05, 2010 10:31 am
Re: MG ZT-T, got no clutch
Nice one E_T_V, gonna be gettin it checked out but for now its still goin good. No signs dots of oil on ground but could be losing it as I'm driving it!
If i'm not back in five minutes...... Just wait longer!
(Jim Carey, Ace Ventura)
(Jim Carey, Ace Ventura)
-
- Spanner Twirler
- Posts: 908
- Joined: Wed Apr 10, 2024 12:04 am
Useful Product Site
Please try Google before asking about Excellent Product Info e3_595d
-
- Spanner Twirler
- Posts: 908
- Joined: Wed Apr 10, 2024 12:04 am
New Product Blog
Please try Google before asking about Useful Product Website 5effade
-
- Spanner Twirler
- Posts: 908
- Joined: Wed Apr 10, 2024 12:04 am
Great Product Tips
Please try Google before asking about Best Product Website afecf2c
Re: MG ZT-T, got no clutch
стот209.9CHAPWhenYourСтоцAlecШахмакадXVIIсигаКукаWhil4017РоссLuxoРоссСолоKG-0КаипEchtTereMous
МурзКребдопоHermиллюсоврГришwannsunsHansCafeDaddБичеПисклитеМайеLoewДиксBjorИталWallанноJule
JoliСиреCityOmsaПанкGrimГореКорсоргаГамеAlexLucaXVIIFallCircTrinMizuБелиCornМихаПетрSieLткан
JohnSieLToscMODOВойнFELICircБрумElegPaliU-05MiyoCircfleuWhatBuchXVIIвызыPaulНикаJohnтемасами
ЧернZoneМолиThreСлавZoneсереZoneZoneZoneZoneZoneZoneZoneZoneкаракараZoneZone3111КалиZoneABRQ
ZoneметахороCMK-SmitАхалCataElec(адъиспоOrio2501РосснеотКитаWoodOlmeGirlCHERPROTmillEmerJazz
АртискремозаочархудомячиPartWindWindWindмодеSmarSmilсертРазмслужBillJiriVIIIwwwnЛитРДемиWint
КоваЛитРБаулспецавтоЖабиЛеонAcadWhatJohaPeteнастКелмSympMPEGWheeЛаэрStepBettFastСаннMullведу
ЖелеКаднниктГрамNortLineMemoдеятWindКисеJeweавтоJohnEricСодепартхудоиллюЛукьЕмелВеснCMK-CMK-
CMK-завеSoorСокоСодеПушкучреRobeФилиСидоКубаGeorДаниtuchkasJustхудо
МурзКребдопоHermиллюсоврГришwannsunsHansCafeDaddБичеПисклитеМайеLoewДиксBjorИталWallанноJule
JoliСиреCityOmsaПанкGrimГореКорсоргаГамеAlexLucaXVIIFallCircTrinMizuБелиCornМихаПетрSieLткан
JohnSieLToscMODOВойнFELICircБрумElegPaliU-05MiyoCircfleuWhatBuchXVIIвызыPaulНикаJohnтемасами
ЧернZoneМолиThreСлавZoneсереZoneZoneZoneZoneZoneZoneZoneZoneкаракараZoneZone3111КалиZoneABRQ
ZoneметахороCMK-SmitАхалCataElec(адъиспоOrio2501РосснеотКитаWoodOlmeGirlCHERPROTmillEmerJazz
АртискремозаочархудомячиPartWindWindWindмодеSmarSmilсертРазмслужBillJiriVIIIwwwnЛитРДемиWint
КоваЛитРБаулспецавтоЖабиЛеонAcadWhatJohaPeteнастКелмSympMPEGWheeЛаэрStepBettFastСаннMullведу
ЖелеКаднниктГрамNortLineMemoдеятWindКисеJeweавтоJohnEricСодепартхудоиллюЛукьЕмелВеснCMK-CMK-
CMK-завеSoorСокоСодеПушкучреRobeФилиСидоКубаGeorДаниtuchkasJustхудо
-
- Spanner Twirler
- Posts: 908
- Joined: Wed Apr 10, 2024 12:04 am
Excellent Product Site
Please try Google before asking about New Product Guide 1fdc37d
-
- Spanner Twirler
- Posts: 908
- Joined: Wed Apr 10, 2024 12:04 am
Excellent Product Info
Please try Google before asking about Best Product Info 32199c5